The recipe is very simple. Just click on the box to the left and it links to my notes.
When I woke this morning I was not planning on making Beef Pastrami but while at Costco I could not resist. This is such an easy recipe. All you have to do is measure out all the ingredients and apply them correctly to the meat.
I cut off the hard pieces of fat first then I used a Jaccard Tenderizer to pierce the meat. Piercing the meat will help with salt the and cure absorption.
I combined the salt and Cure#1 and rubbed it into the meat thoroughly getting every nook and cranny.
I took the whole spices and herbs, (Bay leaf, Grains of Paradise, Coriander, Juniper berries, Whole cloves and mustard seeds) and placed them in a dry pan and applied a little heat to them to bring out their essential oil. I than grounded them up in a spice grinder.
I combined the the ground up spices with the remaining ingredients and applied them to both sides of the meat thoroughly.
All Vacuumed Sealed up and will be flipped every day for 21 days. On May 9, 2014 the Pastrami will be cold smoked for several hours, than SEMI-Hot smoked at a temp of 150 I will than Sous-Vide the Pastrami for 48 hours at a 149 degree water temp.
After 21 days the Brisket is fully cured.
This is my Rub RECIPE for the Pastrami.
Full coated with Rub recipe above. The Brisket will be cold smoke for 4 hours (average temp out side was about 62 degrees). I used Apple pellets and the A-MAXE-N-PELLET-SMOKER.
Now on to the semi-hot smoke. I wanted to impart a hotter smoke flavor to the meat and wanted to raise the temp up slightly
so I filled the water reservoir up with a bucket of ice and water. I used old fashion charcoal and apple wood to smoke the meat. Temp fluctuated between 150-175 degrees. After 4 hours I pulled the meat off. Now getting it ready for 48 hour water bath.
All smoked and ready for the SOUS-VIDE.
SET AT 149 DEGREES.
This is what it looked like after 48 hours.
I wanted to cut into it right away but it was late and I had to get to bed. I submerged the vacuumed sealed bag into an ice bath for an 2 hours to bring down temp than had the wife toss in ice box.
Some final thoughts. It turned out great. I will probably reduce salt from 3.56% down to 2.75% and raise sugar from 2.8% to 3.5%. All in all it turned out very good. Here is the however, if you plan on steaning the pastrami the salt content is fine. The steam extracts some of the salt but a reduction to 3% is probably needed.
I want to stress the importance of steaming. It releases excess salt and makes a good pastrami and exceptional one.
- Coat the outside with a thin layer of spices.
- Cold Smoke
- Semi-Hot-Smoke at about 170-190 degrees for a couple of hours
- Another thin layer of spices
- Semi-Hot-Smoke to create a better bark
- Steam to perfection
Note 1: My suggestion above about the additional smoke after the Sous-Vide to tighten up bark worked well.
Note 2: The addition of Sugar in the rub turned out great too.
Note3: Next time I will try with the following. Sous-Vide first, then Smoke??? This may help eliminate a step.